MitsuStyle MitsuStyle

Go Back   MitsuStyle > The Homefront! > Project Talk

Reply
 
Thread Tools Display Modes
Old 04-13-2012   #141
URV8SUX
 
URV8SUX's Avatar
 

Join Date: Oct 2006
Location: hwy 694
Posts: 308
Re: Mark's 1G Winter Projects

Quote:
Originally Posted by munchgsx View Post


Blue is the EVO
Red is the 1G
Green is LaCroix's Galant
Holy shit I wonder what the red graph would do at 10psi cause it make 800 with .65psi!!!!!!!
URV8SUX is offline   Reply With Quote
Old 04-13-2012   #142
Mark Leasure
 
Mark Leasure's Avatar
 

Join Date: Aug 2006
Location: eagan
Posts: 898
Re: Mark's 1G Winter Projects

Quote:
Originally Posted by Revobasher View Post
So you are on stock transfer case and non built trans still on Evo?
Built ultimate ration trans from Jacks with a 4.11 final drive. MAP spec beast mode Xfercase with a wavetec front diff.
Mark Leasure is offline   Reply With Quote
Old 06-06-2012   #143
Mark Leasure
 
Mark Leasure's Avatar
 

Join Date: Aug 2006
Location: eagan
Posts: 898
Re: Mark's 1G Winter Projects

I’m not going to count on an upgraded T-case anymore. The 1G should make it to the MAP proving grounds with a stock transfer case! I just ordered my yoke conversion to adapt a factory case to a HD DSS 3.5” drive shaft. The off the shelf format from DSS is meant to only work with an upgraded T-case.

Now I need to:
· Tear into the motor to take out the BC280 and install the GSC S3’s
· Replace the timing gear and the keyway on the crank since last time the keyway groove was worn.
· Remove the upgraded TX-case that grenaded.
· Install the new fabricated yoke and factory Tcase.
· Street tune WOT (hopefully the cams will help hold power out further in the band)


The car should be running in a week or two, as normal in the nick of time for the event!

I’m sure it will be hot off the street onto the trailer and heading out to BIR.

Happy days again! Just shooting to get one clean pass in, haha.
Mark Leasure is offline   Reply With Quote
Old 06-06-2012   #144
Tachyon
 
Tachyon's Avatar
 

Join Date: Jun 2004
Location: Prior Lake
Drives: Icarus
Posts: 1,375
Re: Mark's 1G Winter Projects

Nice! glad to see you're still planning on rocking the 1G at the PG!
__________________
"The moment money becomes your motivation, you're immediately not as good as someone who is stimulated by passion and internal will"
-Sebastian Vettel
Tachyon is offline   Reply With Quote
Old 06-06-2012   #145
turbotalon1g
 
turbotalon1g's Avatar
 

Join Date: Mar 2005
Location: Blaine, MN
Drives: '91 Automagic
Posts: 13,908
Send a message via AIM to turbotalon1g
Re: Mark's 1G Winter Projects

Awesome. Good luck those GSC S3s are sick, you should be happy with those.

I hope you get more than one clean pass.
__________________
Aaron/brownman/big brown.
'91 Automagic.
'02 Z06
Please leave feedback - http://www.dsmtuners.com/forums/itrader.php?u=58309
turbotalon1g is offline   Reply With Quote
Old 06-06-2012   #146
Halon
Pewp Champion
 
Halon's Avatar
 

Join Date: Nov 2003
Location: Blaine
Drives: Teh Bean
Posts: 12,309
Send a message via AIM to Halon
Re: Mark's 1G Winter Projects

Damn that sucks your t-case puked on you. Good luck at BIR.
__________________
B-Man - FlexFuel Mafia
1991 TSi AWD E85 - BEP S362, DSMLink V2, Built 2.0L Idle Vid 628hp Graph 541hp Vid 10.93@137 Vid
1992 SC300 E85 - BW 84-75, Vlad Infinity, NA-T, 6spd Idle Vid 709hp Graph 709hp Vid 11.1@131 Vid
2006 Bayliner 195 - Carbed 5.0 Top Speed Test
Halon is offline   Reply With Quote
Old 06-06-2012   #147
CornFed2.4
 
CornFed2.4's Avatar
 

Join Date: May 2005
Location: Linwood, MN
Drives: You crazy!
Posts: 2,354
Send a message via AIM to CornFed2.4
Re: Mark's 1G Winter Projects

Good luck!!!

I also picked up those cams so it will be good to hear what you think. Obviously my setup isnt the exact same but still cool to see what I can expect.
CornFed2.4 is offline   Reply With Quote
Old 06-06-2012   #148
mondale
 

Join Date: Oct 2010
Location: minneapolis, mn
Drives: 1g dsm
Posts: 172
Re: Mark's 1G Winter Projects

Quote:
Originally Posted by CornFed2.4 View Post
Good luck!!!

I also picked up those cams so it will be good to hear what you think. Obviously my setup isnt the exact same but still cool to see what I can expect.
Copious amounts of airflow lol.
__________________
8.59 @ 158
mondale is offline   Reply With Quote
Old 06-07-2012   #149
santa
Boost Spike
 
santa's Avatar
 

Join Date: Oct 2003
Location: Cottage Grove
Drives: 93 talon Automagickinda....
Posts: 1,116
Send a message via AIM to santa
Re: Mark's 1G Winter Projects

If you need a lap top holder for those wot pulls, im your guy!! Good luck Mark!! Hopefully we can line up against each other and confuse everyone which car is which!!
__________________
91 gsx: 734awhp 593ft lbs, best et 10.4@141, @35psi 1.6 60' 2010
93 Talon: 2011 season: Auto, 8.50 cage, For sale!!! $7500
santa is offline   Reply With Quote
Old 06-08-2012   #150
Mark Leasure
 
Mark Leasure's Avatar
 

Join Date: Aug 2006
Location: eagan
Posts: 898
Re: Mark's 1G Winter Projects

Sounds good to me! How's your car coming along?
Mark Leasure is offline   Reply With Quote
Old 06-08-2012   #151
santa
Boost Spike
 
santa's Avatar
 

Join Date: Oct 2003
Location: Cottage Grove
Drives: 93 talon Automagickinda....
Posts: 1,116
Send a message via AIM to santa
Re: Mark's 1G Winter Projects

Driving it up to map in a few minutes to have the nhra chassis inspector check it out. Hopefully it should pass with flying colors. Let me know if you need a hand with your car!
__________________
91 gsx: 734awhp 593ft lbs, best et 10.4@141, @35psi 1.6 60' 2010
93 Talon: 2011 season: Auto, 8.50 cage, For sale!!! $7500
santa is offline   Reply With Quote
Old 06-09-2012   #152
Mark Leasure
 
Mark Leasure's Avatar
 

Join Date: Aug 2006
Location: eagan
Posts: 898
Re: Mark's 1G Winter Projects

Good thing I decided to do a cam swap, I found 3 of the 5 nuts on my adjustable cam gears were finger tight. The shield plate that attaches to the head had one of the small fasteners ready to fall out. Who knows another couple of miles and the whole motor could have been F’d. Now the cam gears have Locktite Red applied.

The idle is a little rougher, not too bad though. You can physically see the difference in the cams when you set them side by side with the S3’s. The S3’s are monsters. I wish I could have done them when I built the motor, since I’m a little concerned about valve to piston clearance. I’m just going to let her buck and see what happens. I took the car around the block in front wheel drive mode and the tires break free at about 15 psi making the care useless. Now I know why transfer cases take so much abuse, it’s like the front have no aid in the traction department. These 1G’s are closer to rear wheel drives.

Now I just need to get the transfer case in it and tune it up, should be exciting!
Mark Leasure is offline   Reply With Quote
Old 06-09-2012   #153
Constant_Project21
 
Constant_Project21's Avatar
 

Join Date: Sep 2008
Location: Saint Paul, MN.
Drives: E36
Posts: 2,269
Re: Mark's 1G Winter Projects

Woo! Good to see a few cars getting ready for proving grounds! I'm excited to see you and Kevin both make some passes in this year. We have to have some fast cars around here, seems there's quite a few really quick 1g's nationwide this year.
Constant_Project21 is offline   Reply With Quote
Old 06-11-2012   #154
Pushit2.0
15min late to the world
Re: Mark's 1G Winter Projects

Most after market pistons have enough room with a 1mm over valve.
__________________
Moon taxi: 9.45@156.9 mph 41psi 2011... Letting people down sense 2012.
Pushit2.0 is offline   Reply With Quote
Old 06-11-2012   #155
Mark Leasure
 
Mark Leasure's Avatar
 

Join Date: Aug 2006
Location: eagan
Posts: 898
Re: Mark's 1G Winter Projects

Good to know John, I took a compression check after I smoked the front tires to almost 8k. All is good!
Mark Leasure is offline   Reply With Quote
Old 06-14-2012   #156
Mark Leasure
 
Mark Leasure's Avatar
 

Join Date: Aug 2006
Location: eagan
Posts: 898
Re: Mark's 1G Winter Projects

I took out the broken transfer case and replaced it with a factory one. Now it's just a matter of some tuning and an oil change to get the new cams dialed in.

Pic of the broken case:




Mark Leasure is offline   Reply With Quote
Old 06-14-2012   #157
tpunx99GSX
 
tpunx99GSX's Avatar
 
Tournaments Won: 3

Join Date: Oct 2003
Location: Maple Grove, MN
Drives: Lancer and Durango
Posts: 7,017
Send a message via ICQ to tpunx99GSX Send a message via AIM to tpunx99GSX Send a message via MSN to tpunx99GSX Send a message via Yahoo to tpunx99GSX
Re: Mark's 1G Winter Projects

Because Racecar.
__________________
Scientific theories are the most reliable, rigorous, and comprehensive form of scientific knowledge. This is significantly different from the common usage of the word "theory", which implies that something is a conjecture, hypothesis, or guess.
tpunx99GSX is offline   Reply With Quote
Old 06-14-2012   #158
turbotalon1g
 
turbotalon1g's Avatar
 

Join Date: Mar 2005
Location: Blaine, MN
Drives: '91 Automagic
Posts: 13,908
Send a message via AIM to turbotalon1g
Re: Mark's 1G Winter Projects

HOLY


Glad you are getting it all taken care of though
__________________
Aaron/brownman/big brown.
'91 Automagic.
'02 Z06
Please leave feedback - http://www.dsmtuners.com/forums/itrader.php?u=58309
turbotalon1g is offline   Reply With Quote
Old 06-15-2012   #159
goodhart
Transmission destroyer
 
goodhart's Avatar
 

Join Date: Feb 2007
Location: Cambridge
Drives: G37, 91 TSi
Posts: 7,150
Send a message via MSN to goodhart
Re: Mark's 1G Winter Projects

I think you need one of these haha

__________________



Quote:
Originally Posted by scheides View Post
I swing from the nuts of cold hard data. Anything less is a guess.
goodhart is offline   Reply With Quote
Old 06-15-2012   #160
turbotalon1g
 
turbotalon1g's Avatar
 

Join Date: Mar 2005
Location: Blaine, MN
Drives: '91 Automagic
Posts: 13,908
Send a message via AIM to turbotalon1g
Re: Mark's 1G Winter Projects

He needs the race version fool!

That thing is $350!
__________________
Aaron/brownman/big brown.
'91 Automagic.
'02 Z06
Please leave feedback - http://www.dsmtuners.com/forums/itrader.php?u=58309
turbotalon1g is offline   Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off



All times are GMT -5. The time now is 06:25 AM.


Powered by vBulletin® Version 3.8.4
Copyright ©2000 - 2024, Jelsoft Enterprises Ltd.