91 Galant VR4 #597 Project redemption
 

This is my new Galant VR4 I picked up last week to get up and running as my new daily. It needs a turbo and the wiring fixed. Along with a hand full of other odds and ends. Tonight I fixed up the engine bay harness that was shortened by someone and when I did get the car home it would not start or run, but now it starts.

http://a7.sphotos.ak.fbcdn.net/hphot...59497782_n.jpg

http://www.mitsustyle.com/photopost/...photos_059.jpg

Its the green on the other side of the race car.

http://www.mitsustyle.com/photopost/...photos_066.jpg

Its kind of weird to see them next to each other.

http://www.mitsustyle.com/photopost/...photos_068.jpg

The turbo is bad, so I will be swapping that out starting tonight. And I am putting power steering back in the car, well the pump was never removed but the AWS was taken out, so I just need to cap the lines going to the back of the car.

http://www.mitsustyle.com/photopost/...photos_070.jpg

Stock, not much to see here

http://hphotos-iad1.fbcdn.net/hphoto...09366603_n.jpg

I looked in the car today and found the factory limited edition key chain.

http://a7.sphotos.ak.fbcdn.net/hphot...25960638_n.jpg

Some body messed with the engine bay harness a little to much.

http://a7.sphotos.ak.fbcdn.net/hphot...12680601_n.jpg

They were doing it wrong.

http://a1.sphotos.ak.fbcdn.net/hphot...75929302_n.jpg

I have a Eprom ECU I will use to tune the car. I am going to put the china evo 3 16g on the car and getting it driving around, then I will put some work into swapping on the mutt level 1 I put on the moon taxi, back in the day, and supporting mods to make a fun daily.

It also has the cyclone dual runner manifold on it now, I will do some thinking on if I can make it work like it should, that would help power under the curve a lot, something the moon taxi has none of, could be fun.

It also has a 4 bolt rear end and a 5 lug swap and a small FMIC with some OK piping. We will see how this comes together in the next week or so.

~John

Re: 91 Galant VR4 #597 Project redemption
 

seems like everyones getting a galant these days

Re: 91 Galant VR4 #597 Project redemption
 

How'd you get it running? JUST curious.

ps: Where do you find all this motivation?

Re: 91 Galant VR4 #597 Project redemption
 

If you look at the pic of the engine bay with the wirering all layer out I cut out every spot you see red shrink tube as they were soldered together there. A few wires for the coil and transistor pack broke as I was stripping the e tape off. So I figure there were a few connections that were not good.

And as for motivation, I am not sure.

~John

Re: 91 Galant VR4 #597 Project redemption
 

so is the HG blown?

Re: 91 Galant VR4 #597 Project redemption
 

Yay for belize green! Looks like a decent pick-up for a daily. Glad to see it in good hands. :)

Re: 91 Galant VR4 #597 Project redemption
 

lol. Nice work JDM.

It will be pimp having 2 GVR4s

Re: 91 Galant VR4 #597 Project redemption
 

Wow nice work rescuing that thing!

Re: 91 Galant VR4 #597 Project redemption
 

I do not know about the hg yet. I will get the turbo swap done then let it warm up all the way.

Re: 91 Galant VR4 #597 Project redemption
 

Whoah sweet! Looks like a good car, if anyone can get this thing back roadworthy you are the man! Good luck and keep us updated!

Re: 91 Galant VR4 #597 Project redemption
 

very nice

Re: 91 Galant VR4 #597 Project redemption
 

I will up date later with more pics and the long list I went threw to make this thing a good DD. kind of funny when I towed it home we had snow, and my test drive tomorrow will be in fresh snow. But the hole time working on it, we had no snow.

Re: 91 Galant VR4 #597 Project redemption
 

Looks cool John are you going to put a trailer hitch on the DD to tow the race car to the track?

Re: 91 Galant VR4 #597 Project redemption
 

Yes I should.

Re: 91 Galant VR4 #597 Project redemption
 

So the long block ended up being just fine then? No HG issues?

Re: 91 Galant VR4 #597 Project redemption
 

I will fully warm up the car today and drive it around the block. I will know for sure then.

Re: 91 Galant VR4 #597 Project redemption
 

So I drove it around a little tonight. The CAS stopped working after it was warmed up, so I swapped that out. There might be a lower end knock on #2 I will put a few more miles on it to see what else I will need to fix. And order some bearings I guess.

Re: 91 Galant VR4 #597 Project redemption
 

updates?

Re: 91 Galant VR4 #597 Project redemption
 

Time for a small update.

Long story short the motor was junk, rod knock and leaks all over, a lot of blow by shot rings and valve seals. The clutch slipped and just about everything bangs or rattles.

So it now has the backup motor, twin disk, and ems from the race car in it.

At wg pressure with a 16g we are at 210hp/220tq.

There will be some changes and a small list of things to make it a good DD.

I will run the 16g till it lets go then a bigger turbo and upgrade the fuel and IC setup.

Re: 91 Galant VR4 #597 Project redemption
 

Just like a Boss ! ha